Putting Glass Walls on Delaware Slaughterhouses So We Can See Behind Closed Doors
Perdue Farms, Delaware

Address: 255 N. Rehoboth Blvd., Milford, DE 19963
Establishment No.: P1318

USDA Inspection Report: 09 Feb 2012

Code: 03J04
Violation: 381.65(e), 417.2(c)(4)

Citation: Evisceration area: At 1450 hours while performing poultry finished product standards on line I observed fecal material on the ninth bird out of a sub group of ten. The fecal was approximately a one inch smear on the right inside back area. The fecal was brown in color and pasty in consistency. Since there was no plant employee between the pre chill station and the chilling system, it is reasonable to conclude the contaminated carcass would have entered the chilling system. Shift Leader, Mr. was immediately notified as well as HACCP Checker Ms. of the failure to meet the requirements of Poultry regulations 9CFR 417.2(c) (4) and 9CFR 381.65 (e) which requires no visible fecal material to enter the chilling system. Immediate corrective actions for CCP # 1 were initiated as per the plant's HACCP plan. The affected bird was reconditioned by management. The reason given by management for the failure was bird was miscut by venter due to one legged bird. A review of the Establishment's CCP # 1 for on line Zero Tolerance Log dated 02/09/2012 revealed that the last acceptable check was performed at 1419 hours by HACCP Technician Ms. with a quantifiable value of 0/10. As a result of this deviation all requirements at all CCPs for that specific lot was performed and found to be acceptable including the pre shipment review at 2025 hours. The establishment failed to meet the requirements of 9CFR 417.2 (c) (4) and 9CFR 381.65 (e). Mr. Plant Manager, is being notified through this noncompliance record of the plant's failure to meet the regulatory requirements of 9CFR 417.2 (c) (4) and 9CFR 381.65 (e) and that a deviation had occurred in their HACCP system. This document serves as written notification that continued failure to comply with the regulatory requirements may result in additional regulatory or administrative action(s) as described in 9CFR 500.4

Regulation:

381.65(e) Poultry carcasses contaminated with visible fecal material shall be prevented from entering the chilling tank.

417.2(c)(4) List the procedures, and the frequency with which those procedures will be performed, that will be used to monitor each of the critical control points to ensure compliance with the critical limits;

Return to: Perdue Farms, Delaware
Return to: Slaughterhouses