Putting Glass Walls on Pennsylvania Slaughterhouses So We Can See Behind Closed Doors
Farmer’s Pride Inc.

Address: 154 West Main St, Fredricksburg, PA, 17026
Establishment No.: p1304

USDA Inspection Report: 7 Dec 2010

Code: 01B02
Violation: 416.13(c), 416.2(d), 416.4(a)

Citation: On Tuesday, 12/07/2010, at approximately 2040 hours, after plant's pre-operational sanitation and prior to the start of operation, I observed the following noncompliance's while performing an unscheduled pre-op sanitation (01B02) procedure, In the (Thigh & Leg Debone Department) the following was observed: I observed condensation on an overhead drip pan and ceiling dripping on product contact surface's (Dumper's and Incline Conveyors) and product zone area in the Thigh and Leg Dumper's areas. I informed (Sanitation Manager) of my observation. I rejected Thigh & Leg Dumper's areas for unsanitary condition with US Rejected Tag B39 801374. The condensations were dripping at these locations approximately every three to five second. A check of the plant SSOP's (Thigh & Leg Debone) shows no documentation for the above noncompliances. These areas were released for USDA inspection at 2030 hours. Establishment management has received oral and written notification concerning this noncompliance. This document serves as a written notification that your failure to comply with regulatory requirement could result in additional enforcement action described in 9 CFR part 500.

Regulation:

416.13(c) Each official establishment shall monitor daily the implementation of the procedures in the Sanitation SOP’s.

416.2(d) Ventilation. Ventilation adequate to control odors, vapors, and condensation to the extent necessary to prevent adulteration of product and the creation of insanitary conditions must be provided.

416.4(a) All food-contact surfaces, including food-contact surfaces of utensils and equipment, must be cleaned and sanitized as frequently as necessary to prevent the creation of insanitary conditions and the adulteration of product.

 

Next Report: USDA Inspection Report: 12 Dec 2010
Previous Report: USDA Inspection Report: 6 Dec 2010

Return to: Farmer’s Pride Inc.
Return to: Pennsylvania Slaughterhouses
Return to: Slaughterhouses